Six points for forklift batteries safe use and maintenance

First, routine inspections

 

1, Level: less than the nominal surface, decrease the battery life, but too little will lead to battery acid damaged by heat, therefore, must always be noted that the electrolyte is sufficient.

 

2, terminal, wire, cover: Always check the junction terminals of the FRU 92P1141 battery, the junction with the wire caused by corrosion due to oxidation at the same time recording if the deformation of the lid, there is the phenomenon fever.

 

3, Appearance: the surface of the soil causes the battery leak should make the battery to keep the area clean and dry.

 

Second, Maintenance

 

1, just add water: In accordance with the provisions of the liquid to add distilled water, do not add water to extend the interval to add too much distilled water, add Water too, overflow leading to electrolyte leakage.

 

2, Charge: Charging the Dell Inspiron 1420 battery will produce gas, should be kept well ventilated places charge around there was no fire, while the oxygen generated during charging, acid gases would have an impact on surroundings. Unplug the charger during the charging socket occur at the arc, after closing the charger before disconnecting the plug. After charging the battery through the remaining number of hydrogen does not flame, should open the lid of the battery to recharge.

 

3, terminal, wire cover the maintenance: the need specified by the manufacturer of professional and technical staff to proceed.

 

4, cleaning: If it is dirty you can clean with a damp cloth, it is very dirty, it is necessary to remove the battery from the car with water after cleaning to dry naturally.

 

Third, the guard

 

1, storage spaces: You can not make a short circuit, leading to a short circuit that may arise due to the rain of fire and may produce a small amount of hydrogen gas, F4486B batteries must be stored in ventilated and cool.

 

2 accumulators: there is still a waste of battery power, the batteries must be stored according to methods used in detention.

 

Fourth, the operation of the electrolyte

 

1, check the proportion of: the use of inhaled hydrometer check the proportion of the electrolyte during the operation does not allow it to spread, and wear protective clothing.

 

2, in addition to checking out the operation: do we need professional advice, in particular, is to complete the acid (sulfuric electrolyte) is used.

 

3, electrolyte leakage: Because the battery switch, broken leading to leakage of electrolyte, should an immediate emergency treatment (refer to address urgent problems)

 

Fifth, end of operation on battery life

 

1, end of operation on battery life: living close to the battery at the end, the single-cell battery electrolyte abates very quickly, add distilled water every day.

 

2, treatment of waste batteries: waste, electrolyte, decomposition of the battery. To negotiate if the manufacturer of the battery recall.

 

Sixth, the handling of emergency

 

1 electrolyte splashed on skin: rinse thoroughly with water

 

2, electrolyte spills for eyes, flush thoroughly with water and then receive professional medical treatment

 

3 spill electrolyte clothing: the immediate Remove clothing, wash with water and then rinse with a weak alkaline soap.

 

4, leakage of electrolyte: electrolyte leakage to the VGP-BPS2 outside, it immediately with lime, high carbonated and carbonated or so in, and rinse thoroughly with water.