Agricultural vehicle battery correct use and maintenance

Battery life with the use of maintenance is closely related to the use of poor maintenance, resulting in damage to the batteries at first, will start agricultural vehicles difficult. Therefore, a prudent maintenance of the VGP-BPS2 battery is very necessary.

1. The proper use of batteries

1.1 To install the batteries correctly Datie pole. The current farm vehicles and generators with battery rectifier is used in negative Datie; with the DC generator is equipped with a battery cathode Datie, remember to install the anti, or they will burn the diode silicon. Battery stack pole marked “+” sign is positive, marked “-” number is negative, no tags, identifies the following characteristics: (1) a very thick pile is positive, the smaller the negative, (2) Battery pole on the oxide is more positive, less negative, (3) a very dark brown pile is positive, the light gray is negative, (4) can also pile on each leads to a bipolar wire inserted in the same cup salt, there are a large number of bubbles generated at one end is negative.

1.2 does not make excessive PB992A battery discharge. Use electric starter begins, each no more than 5 seconds, start-up time continues every 1-2 more minutes, three times to start Buzhao must verify the reason, can not start immediately. Winter starts the engine to heat water, oil must be pre-heated to reduce the load on the starter battery and reduce the current production.

1.3 In case there is no case of cables not, do not force moving plate Chuck wiring to avoid a very loose clusters.

2. Battery Maintenance

2.1 keep the battery clean. The outer surface of discharged electrolyte VGP-BPS10 battery, dirt, dust, causing the discharge of short-circuit must still endure. Chuck A very pious and wiring must be kept in contact, simple, and the ground covered with petroleum jelly or butter, to oxidation. Wind battery cover must remain open to prevent the expansion of gas to allow the breaking shell of the battery.

2.2 The battery must be installed on the locomotive and reliable fixation. And to have anti-vibration pad, so as to avoid driving the shattered shell of the FK890 battery. When they found the shell cracking or electrolyte leakage should be repaired quickly.

2.3 The monitoring of the level of electrolyte fluids regularly, checking fluid levels, the application of two openings in the glass tube, is strictly prohibited the use of the device. Surface is insufficient, it is appropriate to add distilled water (especially in summer), when the Y9943 electrolyte leakage or overflow, when the proportion of the electrolyte should be added to the original. Add distilled water, it should start the engine to recharge, so that the electrolyte mixture.

2.4 check the battery of the deposit. Application of the hydrometer or electrolyte discharge fork measures. If any of these devices can also be the Chairman of the volume, brightness of light to check. Prohibit the use of short-circuit the size of the landfill to check to see spark means a lot to prevent the discharge of the battery, is strictly prohibited conductive tools and objects can be placed on the battery on the battery to prevent damage short-circuit.